Re: Projekt Uber Geizig 1972 VW Bus Deluxe 9 Passenger
Posted: Aug Mon 01, 2011 1:41 pm
by YASHA7FOLD
Almost there Mike.
Re: Projekt Uber Geizig 1972 VW Bus Deluxe 9 Passenger
Posted: Aug Wed 10, 2011 10:28 pm
by Mikewire
Major progress; injectors (post-clean) showed up today.
Installed the injectors and tried to start it, and it just stumbled like it was before. So I ran through the wiring harness again, and traced a wire back to the ECU that seemed out of place. I disconnected it, and the mofo started right up and ran!! After a while of messing with the throttle cable and setting the timing to 7.5 BTDC it runs really well, and starts right up every time.
The cuplrit was this little (disconnected) wire right here:
There's no mention of another wire like it in the Bentley, but when tracing it for continuity I found that it goes back to a terminal on the double relay. So I was actually just grounding out the circuit, which was why I wasn't getting any injector pulse, and was also why I wasn't getting the fuel pump to run with the ignition on and the AFM flap pushed in.
So, now onward. I can't seem to get the clutch to fully release, not sure what's going on there. I tightened up the clutch cable adjuster fairly snug, and it still will not fully release the clutch with the pedal pressed to the floor. Time to do some research.
Video coming soon...
Re: Projekt Uber Geizig 1972 VW Bus Deluxe 9 Passenger
Posted: Aug Wed 10, 2011 11:22 pm
by sneakyboy1
That is soo awesome you got get running man!
Sent from my DROIDX using Tapatalk
Re: Projekt Uber Geizig 1972 VW Bus Deluxe 9 Passenger
Posted: Aug Thu 11, 2011 8:07 am
by MT-Getto
Cheers!
Re: Projekt Uber Geizig 1972 VW Bus Deluxe 9 Passenger
Posted: Aug Thu 11, 2011 8:16 am
by Mikewire
Here's a short video
Re: Projekt Uber Geizig 1972 VW Bus Deluxe 9 Passenger
Posted: Aug Thu 11, 2011 10:45 am
by Roadhog
so that's what 40hp of furry sounds like.
Re: Projekt Uber Geizig 1972 VW Bus Deluxe 9 Passenger
Posted: Aug Thu 11, 2011 1:40 pm
by 4est
70 hp stock for 2.0 type 4. cool video. good luck on the 1st drive.
Re: Projekt Uber Geizig 1972 VW Bus Deluxe 9 Passenger
Posted: Aug Thu 11, 2011 5:53 pm
by YASHA7FOLD
Way to go Mike. Heard some gears grinding. Now for a clutch adjustment. Nice
Re: Projekt Uber Geizig 1972 VW Bus Deluxe 9 Passenger
Posted: Aug Thu 11, 2011 9:41 pm
by padroB5
hats awsome!!!!!!!! glad to hear it running!!! an i like the fire egstigusher in the video
Re: Projekt Uber Geizig 1972 VW Bus Deluxe 9 Passenger
