Low BoOst - Black Smoke under full throttle
Moderator: Mikewire
Re: Low BoOst - Black Smoke under full throttle
more like head gasket if it is white. Are you low on coolant?
- Dubber
- In the drivers seat...
- Posts: 712
- Joined: Apr Thu 17, 2008 2:13 pm
- Vehicles: 2009 Skoda Octavia Ambiente II
- Location: Prague, Czech Republic
- Contact:
Re: Low BoOst - Black Smoke under full throttle
well it looked white - it was dark and i did not get out of the car to check. I will look into my coolant levels.
"We are shaped by our thoughts; We become what we think. When the mind is pure, joy follows like a shadow that never leaves." - Buddha
If you are not happy now, you never will be.
If you are not happy now, you never will be.
- Dubber
- In the drivers seat...
- Posts: 712
- Joined: Apr Thu 17, 2008 2:13 pm
- Vehicles: 2009 Skoda Octavia Ambiente II
- Location: Prague, Czech Republic
- Contact:
Re: Low BoOst - Black Smoke under full throttle
coolant levels are spot on - good thing i take it =)
"We are shaped by our thoughts; We become what we think. When the mind is pure, joy follows like a shadow that never leaves." - Buddha
If you are not happy now, you never will be.
If you are not happy now, you never will be.
- Dubber
- In the drivers seat...
- Posts: 712
- Joined: Apr Thu 17, 2008 2:13 pm
- Vehicles: 2009 Skoda Octavia Ambiente II
- Location: Prague, Czech Republic
- Contact:
Re: Low BoOst - Black Smoke under full throttle
Alright - I finally got the time to take my SMIC off..
I found this...


this was what came out almost immediately. It was still dripping out a while ago when i was checking on it.
I took off the pancake pipe - that was full of oil as well.
Earlier today - while accelerating pretty hard I had a bunch of smoke come out. But again, as with before, if i disconnect the maf sensor, it no longer has the smoke problem..
SO - what does the oil in the SMIC mean?? turbo??
Could i be facing two problems of a different sort here? MAF and Turbo problems??
help appreciated!!
Can i keep driving the car like this?? Or will it hurt it to continue??
I found this...


this was what came out almost immediately. It was still dripping out a while ago when i was checking on it.
I took off the pancake pipe - that was full of oil as well.
Earlier today - while accelerating pretty hard I had a bunch of smoke come out. But again, as with before, if i disconnect the maf sensor, it no longer has the smoke problem..
SO - what does the oil in the SMIC mean?? turbo??
Could i be facing two problems of a different sort here? MAF and Turbo problems??
help appreciated!!
Can i keep driving the car like this?? Or will it hurt it to continue??
"We are shaped by our thoughts; We become what we think. When the mind is pure, joy follows like a shadow that never leaves." - Buddha
If you are not happy now, you never will be.
If you are not happy now, you never will be.
- Dubber
- In the drivers seat...
- Posts: 712
- Joined: Apr Thu 17, 2008 2:13 pm
- Vehicles: 2009 Skoda Octavia Ambiente II
- Location: Prague, Czech Republic
- Contact:
Re: Low BoOst - Black Smoke under full throttle
SO I have read all over on the Vortex - everyone says oil in the intercooler is fine and normal - can anyone support this statement??? its got me concerned =)
My turbo does whine now, but im not sure if its because of the CAI i installed or not... hmm??
thanks a lot guys =)
My turbo does whine now, but im not sure if its because of the CAI i installed or not... hmm??
thanks a lot guys =)
"We are shaped by our thoughts; We become what we think. When the mind is pure, joy follows like a shadow that never leaves." - Buddha
If you are not happy now, you never will be.
If you are not happy now, you never will be.
- Mikewire
- Site Admin
- Posts: 4090
- Joined: Oct Thu 20, 2005 1:23 am
- Vehicles: Air and Water
- Location: San Antonio, TX
- Contact:
Re: Low BoOst - Black Smoke under full throttle
Yes, some oil is normal. If your IC has never been checked I would say it's leftover/old and the amount you got out is normal. Your CAI will def. increase turbo spool noise. If you are worried, put your old intake back on and compare the noise.
Like I said earlier you could pull the intake side and see if you can wiggle the turbo shaft - if you have excessive play then your turbo bearings are out of spec and it would explain the excessive oil in your IC (it also could be old oil that has never been drained from the IC). The next step would be to have the turbo rebuilt or replaced.
Now about your boost pressure, here's a pressure test link - the vortex is great for reference:
http://forums.vwvortex.com/zerothread?id=2692757
Personally I would use PVC, but the can works too. Put it all back together and pressure test it --- don't go over 20PSI!
You should also have clamps at all junction points where the charge pipes meet or join up - nothing should be just pushed together. So if you are missing a clamp you are probably losing boost there.
Like I said earlier you could pull the intake side and see if you can wiggle the turbo shaft - if you have excessive play then your turbo bearings are out of spec and it would explain the excessive oil in your IC (it also could be old oil that has never been drained from the IC). The next step would be to have the turbo rebuilt or replaced.
Now about your boost pressure, here's a pressure test link - the vortex is great for reference:
http://forums.vwvortex.com/zerothread?id=2692757
Personally I would use PVC, but the can works too. Put it all back together and pressure test it --- don't go over 20PSI!
You should also have clamps at all junction points where the charge pipes meet or join up - nothing should be just pushed together. So if you are missing a clamp you are probably losing boost there.
2015 Porsche Macan S
2021 VW Atlas SEL Premium 4-Motion
1972 VW Kombi 9 Passenger Deluxe w/ 2.0L F.I. VWAC
1965 VW Beetle
FAQ | Forum rules
- Dubber
- In the drivers seat...
- Posts: 712
- Joined: Apr Thu 17, 2008 2:13 pm
- Vehicles: 2009 Skoda Octavia Ambiente II
- Location: Prague, Czech Republic
- Contact:
Re: Low BoOst - Black Smoke under full throttle
Where would you go to buy a new turbo?? how about where to go to have it rebuilt??
Would it be worth stepping up to a Ko4 If its purely just bolt ons??
Would it be worth stepping up to a Ko4 If its purely just bolt ons??
"We are shaped by our thoughts; We become what we think. When the mind is pure, joy follows like a shadow that never leaves." - Buddha
If you are not happy now, you never will be.
If you are not happy now, you never will be.
- Dubber
- In the drivers seat...
- Posts: 712
- Joined: Apr Thu 17, 2008 2:13 pm
- Vehicles: 2009 Skoda Octavia Ambiente II
- Location: Prague, Czech Republic
- Contact:
Re: Low BoOst - Black Smoke under full throttle
anyone have any advice on a new turbo? rebuilding it or what??
"We are shaped by our thoughts; We become what we think. When the mind is pure, joy follows like a shadow that never leaves." - Buddha
If you are not happy now, you never will be.
If you are not happy now, you never will be.
- JayRyan
- Spoolin!
- Posts: 834
- Joined: Jun Sat 16, 2007 11:00 pm
- Vehicles: '14 Sequoia, ‘11 Sprinter
- Location: Billings
Re: Low BoOst - Black Smoke under full throttle

‘14 Sequoia
'11 Sprinter 170” Diesel 2WD
Former Dubs:
'03 A4 1.8TQM Modifcations
'04 Jetta VR6M GLI - Silvery
'99 Passat 1.8TM - Emerald Green
'88 Fox GL 1.8M - Brown...gold?
'11 Sprinter 170” Diesel 2WD
Former Dubs:
'03 A4 1.8TQM Modifcations
'04 Jetta VR6M GLI - Silvery
'99 Passat 1.8TM - Emerald Green
'88 Fox GL 1.8M - Brown...gold?